1、沼氣質量
1. Biogas quality
利用沼氣發電，滿足沼氣發電機組對沼氣質量的要求，《中大功率沼氣發電機組》(GBT29488-2003)、《沼氣電站技術規范》(NY/T1704-2009)對沼氣質量的要求如下。
To use biogas for power generation, the first step is to meet the requirements of biogas power generation units for biogas quality. The requirements for biogas quality in the "Medium and High Power biogas power generation units" (GBT29488-2003) and "Technical Specifications for biogas power plants" (NY/T1704-2009) are as follows.
(1) 沼氣低位發熱值≥14MJ/Nm，相當于沼氣中甲烷體積分數不小于30%。沼氣中甲烷在30s內的體積分數變化率不應超過2%，機組連續運行期間沼氣中甲烷體積分數變化率不超過5%。
(1) The low calorific value of biogas is ≥ 14MJ/Nm, which is equivalent to a methane volume fraction of no less than 30% in biogas. The change rate of methane volume fraction in biogas within 30 seconds should not exceed 2%, and the change rate of methane volume fraction in biogas during continuous operation of the unit should not exceed 5%.
(2) 沼氣溫度不高于50℃。
(2) The temperature of biogas shall not exceed 50 ℃.
(3) 沼氣發電機組對沼氣成分的具體要求如下表。
(3) The specific requirements for biogas composition of biogas generator units are shown in the table below.
注：沼氣體積的標準參比條件是101.3kPa，20℃；按照沼氣中所含硫成分全部轉化為硫化氫計算。
Note: The standard reference conditions for biogas volume are 101.3kPa, 20 ℃; Calculate based on the conversion of all sulfur-containing components in biogas into hydrogen sulfide.
①H2S對發電機組的影響
① The impact of H2S on generator sets
沼氣發電時沼氣中的H2S會對沼氣發電機組的進氣管道、增壓器、中冷器、火花塞、氣缸套、排氣管和消音器等造成嚴重腐蝕，從而影響機組壽命，所以沼氣在進入發電機組之前必須進行沼氣預處理，將H2S降到機組允許的范圍內才能保證機組的可靠運行。
During biogas power generation, H2S in biogas will cause serious corrosion to the intake pipe, supercharger, intercooler, spark plug, cylinder liner, exhaust pipe and silencer of the biogas generator set, thus affecting the service life of the unit. Therefore, biogas must be pretreated before entering the generator set, and the reliable operation of the unit can be ensured only by reducing H2S to the allowable range of the unit.

②水分對發電機組的影響
② The impact of moisture on generator sets
沼氣發電過程中，沼氣水分含量過大，會導致發電機組的進氣壓力損耗過大，嚴重情況下，會引起發動機功率波動、敲缸、停機等問題，嚴重地影響其使用壽命。其具體表現為：
In the process of biogas power generation, excessive moisture content in biogas can lead to excessive loss of intake pressure of the generator set. In severe cases, it can cause problems such as engine power fluctuations, cylinder knocking, and shutdown, seriously affecting its service life. Its specific manifestation is:
(a)發動機點火困難；
(a) Difficulty in engine ignition;
(b)降低燃燒室溫度，降低內燃機效率；
(b) Reduce the temperature of the combustion chamber and reduce the efficiency of the internal combustion engine;
(c)水蒸氣等無功氣體的存在，會增壓和增大功耗；
(c) The presence of reactive gases such as water vapor can increase pressure and power consumption;
(d)水蒸氣與其他酸性物質化合產生的中間產物，會對發電機組產生腐蝕，縮短使用壽命，降低可靠性。
(d) The intermediate products produced by the combination of water vapor and other acidic substances can corrode the generator set, shorten its service life, and reduce its reliability.
③粉塵對發電機組的影響
③ The impact of dust on generator sets
粉塵是發動機明確限制的雜質，它主要影響在于：
Dust is a clearly restricted impurity in engines, and its main impact is:
(a)堵塞管路，流通不暢，加大壓損，增加運行費用；
(a) Blocking the pipeline, poor circulation, increased pressure loss, and increased operating costs;
(b)增大機械磨損，降低設備使用壽命。
(b) Increase mechanical wear and reduce equipment service life.
2、沼氣壓力
2. Biogas pressure
沼氣發電機組在距離機組燃氣支管錢1m處的沼氣壓力不低于3kPa，當供氣壓力低于3kPa時，應配置氣體增壓設備；當供氣壓力超過5kPa時，則需要增加合適的減壓閥。在沼氣發電機組運行時，發動機允許的沼氣壓力波動一般要小于0.4kPa/s。
The biogas pressure of the biogas generator set at a distance of 1 meter from the gas branch pipe of the unit shall not be less than 3 kPa. When the gas supply pressure is less than 3 kPa, gas boosting equipment shall be equipped; When the gas supply pressure exceeds 5kPa, it is necessary to add a suitable pressure reducing valve. When the biogas generator set is running, the allowable biogas pressure fluctuation of the engine is generally less than 0.4kPa/s.
3、沼氣用量
3. Biogas consumption
沼氣發電機組的沼氣用量應根據發電機組的效率和負荷確定，發電時沼氣的供氣量應相對穩定。在計算沼氣使用量時，應小于沼氣發電機額定功率耗氣量的1.2倍。供氣系統應設有調節用氣的設施和氣體計量儀表。沼氣發電機組連續運行時，儲氣裝置容量應按照運行機組總額定功率大于3h的用氣量設計。沼氣發電機組間歇運行時，儲氣裝置容量應按照大于間斷發電時間的沼氣總量設計。
The amount of biogas used in a biogas generator set should be determined based on the efficiency and load of the generator set, and the supply of biogas during power generation should be relatively stable. When calculating the usage of biogas, it should be less than 1.2 times the rated power consumption of the biogas generator. The gas supply system should be equipped with facilities for regulating gas consumption and gas measuring instruments. When the biogas generator unit operates continuously, the capacity of the gas storage device should be designed based on the total rated power of the operating unit exceeding 3 hours of gas consumption. When the biogas generator unit operates intermittently, the capacity of the gas storage device should be designed based on the total amount of biogas greater than the intermittent power generation time.
其中，沼氣發電機組的用氣調節系統，一般采用電子調速系統控制碟門開度來實現的，調速系統由轉速傳感器、速度控制器、執行器和驅動器組成，構成閉環的速度調節與控制系統，實現對混合氣體進氣量的控制。氣體計量儀表一般是采用沼氣流量計，如銳意自控超聲波氣體流量計BF-3000/BF-3000B，用以實時計量沼氣的瞬時流量和累計流量，為計算沼氣使用量提供科學的數據支撐。
Among them, the gas regulation system of the biogas generator unit is generally achieved by using an electronic speed regulation system to control the opening of the disc door. The speed regulation system consists of a speed sensor, speed controller, actuator, and driver, forming a closed-loop speed regulation and control system to achieve control of the mixed gas intake volume. Gas measuring instruments generally use biogas flow meters, such as the Ruiyi self-control ultrasonic gas flow meter BF-3000/BF-3000B, to measure the instantaneous and cumulative flow of biogas in real-time, providing scientific data support for calculating biogas usage.
本文由沼氣發電機組友情奉獻.更多有關的知識請點擊:http://dgtmcnc.com真誠的態度.為您提供為全面的服務.更多有關的知識我們將會陸續向大家奉獻.敬請期待.
This article is dedicated by the biogas generator unit. For more relevant knowledge, please click on: http://dgtmcnc.com Sincere attitude. We will provide you with comprehensive services. We will gradually contribute more relevant knowledge to everyone. Stay tuned